Product ID:F-12065 CONVERTER ORGANIC COATING
MSDS Date:03/05/1991
FSC:8030
NIIN:00-498-5268
MSDS Number: CCGFS

SEAGRAVE COATINGS CORP OF DELAWARE

320 PATTERSON PLANK RD
CARLSTADT, NJ 07072-5000
US

Emergency Phone: 201-933-1000

Info Phone: 201-933-1000

Cage: DO631

SEAGRAVE COATINGS CORP.

UNKNOW PORTSMOUTH, VA 23701 US

Telephone: 1-800-424-9300

Cage: 6AF43

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-3*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 20%

BUTYL ACETATE (N-BUTYL ACETATE) *95-3*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE

CAS: 28182-81-2

RTECS: NQ9170000

Fraction By Weight: 35%

AROMATIC POLYISOCYANATE

Fraction By Weight: 30%

3.4 LB/GAL; 408 GM/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ISOCYANATE-INHALATION: IRRITANT,
BURNING SENSATION OF THE MUCOUS MEMBRANES IN THE RESPIRATORY TRACT.
CERTAIN INDIVIDUALS WILL DEVELOP SENSITIZATION/CHEMICAL ASTHMA.
OVEREXPOSURE MAY CAUSE LUNG DAMAGE/ DECREASE IN LUNG FUNCTION.
SKIN/EYES: IRRITANT. INGESTION: HARMFUL. (SEE SUPPLEMENTAL DATA)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ISOCYANATES-BURNING SENSATION, RUNNY NOSE, SORE
THROAT, COUGHING, CHEST DISCOMFORT, SHORTNESS OF BREATH, REDUCED
LUNG FUNCTION (BREATHING OBSTRUCTION), ASTHMA, CHEST TIGHTNESS,
WHEEZING, REDDENING, SW ELLING, RASH, SCALING/BLISTERING OF SKIN,
STINGING SENSATION, NARCOSIS, IRRITATION
Medical Cond Aggravated by Exposure:PERSONS W/ASTHMA & OTHER
RESPIRATORY DISORDERS (BRONCHITIS, EMPHYSEMA, HYPERREACTIVITY),
SKIN ALLERGIES, ECZEMA.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER. INGESTION:
DON'T INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS.
OBTAIN MED ICAL ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:80F
Lower Limits:1
Upper Limits:13.1
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, WATER FOG
Fire Fighting Procedures:USE EMERGENCY EQUIPMENT W/SCBA & FULL
PROTECTIVE CLOTHING. USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING. WATER MAY BE USED W/FOG NOZZLES TO COOL CONTAINER
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID/VAPOR. VAPORS MAY
MIGRATE TO IGNITION SOURCE & CAUSE FLASH FIRE. CLOSED CONTAINER MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. (SEE SUPP)

Spill Release Procedures:ABSORB W/INERT MATERIAL. PLACE IN CLOSED
CONTAINERS.

Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS
AWAY FROM HEAT & IGNITION SOURCES. STORE IN A COOL, DRY AREA
W/SUITABLE VENTILATION. GROUND CONTAINER WHILE POURING
Other Precautions:EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES &
CAN BE DANGEROUS. AVOID PROLONGED SKIN CONTACT. DON'T BREATHE SPRAY
MIST.

Respiratory Protection:AN AIR PURIFYING/FRESH AIR SUPPLIED RESPIRATOR.
APPROVED CHEMICAL/MECHANICAL FILTERS ARE RECOMMENDED WHEN
VENTILATION IS RESTRICTED. WEAR NIOSH/MSHA APPROVED RESPIRATOR
DURING & AFTER APPLICATION UNLE SS AIR MONITORING IS LIMITS.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP AIR CONTAMINATION
Protective Gloves:CHEMICAL RESISTANT PLASTIC/RUBBER
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS
Other Protective Equipment:FACE SHIELD, PROTECTIVE CREAMS, EYE BATH,
SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE HAZARD CONT'D: CLOSED CONTAINER MAY BURST WHEN CONTAMINATED
W/WATER. STAGNANT AIR CAUSES VAPORS TO ACCUMULATE, TRAVEL ALONG THE
GROUND TO AN IGNITION SOURCE/FLASHBACK. HEALTH HAZ CONT'D: OVEREXPO
SURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY INHALING, MAY BE HARMFUL/FATAL

Boiling Pt:B.P. Text:259-302F
Vapor Density:>1
Percent Volatiles by Volume:44.4

Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS & SURFACE ACTIVE
MATERIALS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:MOISTURE, HEAT, SPARKS, OPEN FLAME,
ELECTRICAL EQUIPMENT, PILOT LIGHTS, TEMPS >400F & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN
Conditions to Avoid Polymerization:MOISTURE/OTHER MATERIALS WHICH REACT
W/ISOCYANATES/TEMPS >400F & OTHER IGNITION SOURCES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.